Viaduct construction with movable scaffolding system: distribution of the top slab weight

José Ramón Díaz de Terán; Vladimir Guilherme Haach

doi:10.7409/rabdim.015.016

Published: 2016-01-13

Vol. 14 No. 4 (2015)

Viaduct construction with movable scaffolding system: distribution of the top slab weight

José Ramón Díaz de Terán , Vladimir Guilherme Haach

Section: Articles

https://doi.org/10.7409/rabdim.015.016

Abstract

The construction of viaducts with Movable Scaffolding System (MSS) is a sophisticated. However, the construction sequence has a disadvantage of an insufficiently clear distribution of the top slab weight between the scaffolding and the first casting phase of the deck. In order to solve this problem designers assume that the whole weight of the top slab is supported by the scaffolding. In fact, if the whole weight is supposed to be resisted by the scaffolding, it implies that heavier, stiffer and more expensive scaffoldings must be chosen to construct a viaduct. If the distribution of the top slab weight between the scaffolding and the first casting phase is clarified, the scaffolding can be chosen to resist lower loads, so as to lighter and cheaper scaffoldings can be selected. Moreover, if the top slab weight distribution is clarified, the stresses both at the deck and at the scaffolding can be determined more accurately. The contribution of this paper consists in clarifying the weight distribution between the first casting phase and the scaffolding. In order to achieve this objective, it identifies a number of parameters and investigates the importance of the hanger stiffness, as well as the influence of the first casting phase and the scaffolding stiffness.

Keywords:

bridge construction sequence, distribution of top slab weight, first casting phase, Movable Scaffolding System

Similar Articles

Czesław Machelski, Parameters of load transverse distribution across bridges , Roads and Bridges - Drogi i Mosty: Vol. 13 No. 2 (2014)
Thai Thi Kim Chi, Numerical study of debris flows around bridge piers , Roads and Bridges - Drogi i Mosty: Vol. 21 No. 4 (2022)
Monika Podwórna, Marian Klasztorny, The influence of rail-vehicles’ properties on dynamic response of a beam bridge , Roads and Bridges - Drogi i Mosty: Vol. 10 No. 3 (2011)
Piotr Olaszek, Artur Sakowski, Ewa Twardosz, Paweł Nurek, Tests of dynamic impact from trains on noise barriers , Roads and Bridges - Drogi i Mosty: Vol. 19 No. 4 (2020)
Rafał Maciaszek, The bridge over the Ina River – the history and the analysis of capacity , Roads and Bridges - Drogi i Mosty: Vol. 8 No. 3 (2009)
Marek Mistewicz, Risk assessment of the use of corrugated metal sheets for construction of road soil-shell structures , Roads and Bridges - Drogi i Mosty: Vol. 18 No. 2 (2019)
Henryk Zobel, Artur Zbiciak, Radosław Oleszek, Rafał Michalczyk, Przemysław Mossakowski, Numerical identification of the dynamic characteristics of a steel-concrete railway bridge , Roads and Bridges - Drogi i Mosty: Vol. 13 No. 3 (2014)
Jarosław Bęc, Tomasz Lipecki, Andrzej Flaga, Grzegorz Bosak, Model investigations and numerical analysis of an arch shaped footbridge , Roads and Bridges - Drogi i Mosty: Vol. 12 No. 4 (2013)
Czesław Machelski, Steel plate curvatures of soil-steel structures during construction and exploitation , Roads and Bridges - Drogi i Mosty: Vol. 15 No. 3 (2016)
Wojciech Bańkowski, Renata Horodecka, Marcin Gajewski, Krzysztof Mirski, The extended assessment of warm mix asphalts durability , Roads and Bridges - Drogi i Mosty: Vol. 15 No. 2 (2016)

<< < 1 2 3 4 5 6 7 8 9 10 > >>

You may also start an advanced similarity search for this article.

Download files

PDF

Citation rules

Díaz de Terán, J. R., & Haach, V. G. (2016). Viaduct construction with movable scaffolding system: distribution of the top slab weight. Roads and Bridges - Drogi I Mosty, 14(4), 241–255. https://doi.org/10.7409/rabdim.015.016

Cited by / Share

References

Daebritz M., Lee M.: Span by span movable scaffolding systems. IABSE WG 6. State of art of bridge deck erection. Safe and efficient use of special equipment. IABSE, Singapore, 2010
Google Scholar

Povoas A.: A modern Concept of Movable Scaffolding System. Advances in Bridge Maintenance, Safety Management and Life Cycle Performance. Proceedings of the Third International Conference on Bridge Maintenance, Safety and Management, Porto, 2006
Google Scholar

Pacheco P., Fonseca A., Resende A., Campos R.: Sustainability processes in bridge construction process. Clean Technologies and Environmental Policy, 12, 1, 2014, 75-82
Google Scholar

Díaz de Terán J.R., Haach V.G., Turmo J., Jorquera J.: Improved construction of concrete viaducts with movable scaffolding systems in Spain. Submitted and accepted by Journal of Bridge Engineering, March 2015
Google Scholar

Leonhardt F.: Brücken. Bridges. Deutsche Verlagsanstalt DVA, Stuttgart, 1994
Google Scholar

Pacheco P., Adăo da Fonseca A.: Organic prestressing. Journal of Structural Engineering, 128, 3, 2002, 400-405
Google Scholar

Pacheco P., Guerra A., Borges P., Coelho H.: A Scaffolding System strengthened with Organic Prestressing – the first of a new Generation of Structures. Structural Engineering International, 17, 4, 2007, 314-321
Google Scholar

Pacheco P., Coelho H., Borges P., et al.: Technical Challenges of Large Movable Scaffolding Systems. Structural Engineering International, 21, 4, 2011, 450-455
Google Scholar

Díaz de Terán J.R.: Nuevo procedimiento constructivo de viaductos con cimbra autolanzable y nueva secuencia evolutiva (New constructive procedure of viaducts with movable scaffolding system and new evolutionary sequence). PhD thesis, Universitat Politčcnica de Catalunya BarcelonaTech (UPC), Barcelona, 2013, http://www.tdx.cat/handle/10803/129689
Google Scholar

Díaz de Terán J.R., Turmo J., Jorquera J., Barragán B., Ramos G., Aparicio A.: Optimization of in situ construction of concrete decks: Flexure tests of compact splices of reinforcement between phases. Construction and Building Materials, 41, 4, 2013, 191-203
Google Scholar

Díaz de Terán J.R., Turmo J., Jorquera J., Barragán B., Ramos G., Aparicio A.: Shear-off strength of compact reinforcement for improved splicing site construction of concrete structures. Construction and Building Materials, 47, 2013, 199-207
Google Scholar

Mozos C., Caballero A., Serrano J., Prieto S.: Análisis de la optimización del proceso constructive de grandes viaductos de hormigón de luces medias (Optimization analysis of construction process of large concrete viaducts with medium spans). Proceedings of the IV Congress of the Scientific and Technical Association for Structural Concrete (ACHE), Valencia, 2008
Google Scholar

González F., Alcalá J.: Viaducto sobre el barranco de Magallán en la autovía A-23 Sagunto-Somport. Proceedings of the IV Congress of the Scientific and Technical Association for Structural Concrete (ACHE), Valencia, 2008
Google Scholar

Pascual J., Viartola L.: Viaducto sobre el río Genil, en la LAV Córdoba-Málaga. Proceedings of the III Congress of the Scientific and Technical Association for Structural Concrete (ACHE), 3, 2005, 1971-1984
Google Scholar

Crespo J., Glez de Cangas J., Lorenzo D.: Viaducto del río Moutas. Proceedings of the IV Congress of the Scientific and Technical Association for Structural Concrete (ACHE), Valencia, 2008
Google Scholar

Turmo J., Ramos G., Serrano J., Mozos C., Aparicio A., Prieto S., et al.: Implicaciones estructurales de la reducción del camino critic en la construcción de viaductos de hormigón de luces medias (Structural implications of the reduction of the critical path in the construction of concrete viaducts with medium spans). Proceedings of the IV Congress of the Scientific and Technical Association for Structural Concrete (ACHE), Valencia, 2008
Google Scholar

Tamayo P.G., Quell E.B.: Auxiliary temporary work structures. Enllaç, Butlletí Informatiu Cole – Legi d’Enginyers Tčcnics d’Catalan. Public Works, 2009, 20-22
Google Scholar

SEOPAN, Comisión Tecnológica. Manual de diseńo y uso de cimbras autolanzables (Handbook of design and use of movable scaffolding systems). Confederación Nacional de la Construcción, 2007
Google Scholar

Formwork and Falsework for Heavy Construction. FIB, Bulletin 48, 2009
Google Scholar

Diseńo y uso de cimbras (Design and use of formworks). ACHE, Colegio de Ingenieros de Caminos, Canales y Puertos, Madrid, 2005
Google Scholar

Manterola J.: Puentes. Apuntes para su diseńo, cálculo y construcción (Bridges. Notes for design, calculation and construction). Colegio de Ingenieros de Caminos, Canales y Puertos, Madrid, 2006
Google Scholar

Ońate E.: Cálculo de estructuras por el método de los elementos finitos. Análisis estático y lineal (Structure calculation by the finite element method. Static and lineal analysis). CIMNE, Barcelona, 1995
Google Scholar

Zienkiewicz O.C.: El método de los elementos finitos. The finite element method. CIMNE, Barcelona, 1980
Google Scholar

Zienkiewicz O.C., Taylor R.L.: El método de los elementos finitos. Formulación básica y problemas lineales (The finite element method. Basic formulae and lineal problems). Mc Graw-Hill, Barcelona, 1994
Google Scholar

José Ramón Díaz de Terán

jringcamjunior@gmail.com

Affiliation:

University of Sao Paulo, Department of Structural Engineering

Vladimir Guilherme Haach

Affiliation:

University of Sao Paulo, Department of Structural Engineering

Viaduct construction with movable scaffolding system: distribution of the top slab weight

Abstract

Keywords:

Similar Articles

Downloads

José Ramón Díaz de Terán

Vladimir Guilherme Haach