Design and evaluation of stone matrix asphalt using stiffer grade crumb rubber modified bitumen

Gajendra Kumar; Umesh C. Sahoo; K. Ramachandra Rao; Sunil Bose

doi:10.7409/rabdim.019.010

Published: 2019-06-30

Vol. 18 No. 2 (2019)

Design and evaluation of stone matrix asphalt using stiffer grade crumb rubber modified bitumen

Gajendra Kumar , Umesh C. Sahoo , K. Ramachandra Rao , Sunil Bose

Section: Articles

https://doi.org/10.7409/rabdim.019.010

Abstract

Stone Matrix Asphalt (SMA) is primarily used as a surfacing layer material since it is found to perform well under heavy traffic conditions and at the same time is more cost-effective when compared to the conventional dense graded mixes. An attempt has been made in this study to incorporate a stiffer grade crumb rubber modified bitumen (CRMB) for design of SMA. Extensive laboratory studies on mixes prepared with different modified binders and normal binders (with fibers) were conducted. The results obtained indicate that SMA designed using CRMB-70 and CRMB-80 performs well under heavy traffic conditions and at the same time without significant drain-down. Further, CRMB-80 is found to be suitable at high temperatures since it yields a very low accumulated strain and is thus recommended for designing rut resistant durable mixes. In addition, CRMB-80 yields the least rut depth of 4.5 mm even after 20,000 load repetitions.

Keywords:

crumb rubber modified bitumen (CRMB), fiber, performance, stone matrix asphalt (SMA).

Similar Articles

Aleksandr Ganyukov, Adil Kadyrov, Kyrmyzy Balabekova, Bakyt Kurmasheva, Tests and calculations of structural element of temporary bridges , Roads and Bridges - Drogi i Mosty: Vol. 17 No. 3 (2018)
Marian Tracz, Mariusz Kieć, Development and upgrading of two-lane single road network in Poland , Roads and Bridges - Drogi i Mosty: Vol. 15 No. 3 (2016)
Andrea Gorino, Alessandro P. Fantilli, Bernardino Chiaia, Optimization of hybrid reinforcement in precast concrete linings using numerical analysis , Roads and Bridges - Drogi i Mosty: Vol. 16 No. 4 (2017)
Jacek Sudyka, Przemysław Harasim, Monika Kowalska-Sudyka, Tomasz Mechowski, Quality control of Traffic Speed Deflectometer measurements on road network , Roads and Bridges - Drogi i Mosty: Vol. 20 No. 4 (2021)
Marek Pszczoła, Low temperature cracking of asphalt layers of pavements , Roads and Bridges - Drogi i Mosty: Vol. 5 No. 3 (2006)
Mieczysław Słowik, Przemysław Adamczak, Evaluation of short-term ageing influence on the properties of sbs elastomer modified road bitumens , Roads and Bridges - Drogi i Mosty: Vol. 6 No. 1 (2007)
Jacek Zygmunt, Grzegorz Prokopski, Properties of cement concretes modified by mechanically activated siliceous fly ash , Roads and Bridges - Drogi i Mosty: Vol. 8 No. 2 (2009)
Angelika G. Batrakova, Dmitry O. Batrakov, Mariya S. Antyufeyeva, Pavement deterioration model based on GPR datasets , Roads and Bridges - Drogi i Mosty: Vol. 17 No. 1 (2018)
Salvatore Cafiso, Carmelo D'agostino, Mariusz Kieć, Giuseppina Pappalardo, Surrogate measure of safety from road inspection data - experimental test on Polish roads , Roads and Bridges - Drogi i Mosty: Vol. 16 No. 2 (2017)
Dominik Pisarski, Czesław Bajer, Active damping of vibrations of one dimensional continuum under a moving load , Roads and Bridges - Drogi i Mosty: Vol. 8 No. 4 (2009)

<< < 6 7 8 9 10 11 12 13 14 > >>

You may also start an advanced similarity search for this article.

Download files

PDF

Citation rules

Kumar, G., Sahoo, U. C., Rao, K. R., & Bose, S. (2019). Design and evaluation of stone matrix asphalt using stiffer grade crumb rubber modified bitumen. Roads and Bridges - Drogi I Mosty, 18(2), 151–165. https://doi.org/10.7409/rabdim.019.010

Cited by / Share

References

Bellin P.: Use of Stone Matrix Asphalt in Germany - State of the Art. Report Prepared for A2F02 Committee 71st Annual Meeting, Transportation Research Board, Washington, D.C., 1992
Google Scholar

Stuart K.D.: Stone Matrix Asphalt (SMA) Mixture Design. Report No. FHWA-RD-92-006, Federal Highway administration, U.S. Department of Transportation, Washington, D.C., 1992
Google Scholar

Mogawer W.S., Stuart K.D.: Evaluation of Stone Matrix Asphalt versus Dense-Graded Mixtures. Transportation Research Record, 1454, Transportation Research Board, National Research Council, Washington, D.C., 1994, 58-65
Google Scholar

Brown E.R.: Evaluation of Stone Matrix Asphalt Used in Michigan in 1991. Transportation Research Record. 1427, Transportation Research Board, National Research Council, Washington, D.C., 1993, 54-60
Google Scholar

Reinke G.: Laboratory Investigation into the Impact of Polymer Type, Polymer Concentration, and Aggregate Gradation on the Properties of Stone Matrix Mixes. Electronic Journal of Association of Asphalt Paving Technologies, 62, 1993, 314-343
Google Scholar

Davidson J.K., Kennepohl G.J.: Introduction to Stone Matrix Asphalt in Ontario. Meeting of the Association of Asphalt Paving Technologists, Charleston, SC, 1992, Association of Asphalt Paving Technologists, Charleston, SC, 517-534
Google Scholar

Brown E.R.: Experience with Stone Matrix Asphalt in the United States. NCAT Report No. 93, National Centre for Asphalt Technology, Auburn University, Auburn, AL, 1992
Google Scholar

Tung-Wen H., Jeng-Thoa L.: Evaluation of Permanent Deformation of Stone Matrix Asphalt Mixtures. Annual Meeting of the Transportation Research Board, January 11-15, 1998, National Research Council, Washington, D.C.
Google Scholar

Brown E.R., Mallick R.B., Haddock J.E., Bukowski J.: Performance of Stone Matrix Asphalt (SMA) Mixtures in the United States. Electronic Journal of Association of Asphalt Paving Technologies, 66, 1997, 426-457
Google Scholar

Brown E.R., Mallick R.B., Haddock J.E., Bukowski J.: Development of a Mixture Design Procedure for Stone Matrix Asphalt. Electronic Journal of Association of Asphalt Paving Technologies, 66, 1997, 1-32
Google Scholar

Karnemaat R.J., Vreibel D.J., Van Deusen C.H.: Stone Matrix Asphalt: Introduction of Loose Cellulose Fibers into Drum Mix Plant. TRB, National Research Council, Washington, D.C., 1993
Google Scholar

Stuart K.D., Malmquist P.: Evaluation of Using Different Stabilizers in the U.S. Route 15 (Maryland) Stone Matrix Asphalt (SMA). Transportation Research Record, 1454, Transportation Research Board, National Research Council, Washington, D.C., 1994, 48-57
Google Scholar

Harris B.M., Stuart K.D.: Analysis of Using Mineral Fillers and Mastics Used in Stone Matrix Asphalt. Electronic Journal of Association of Asphalt Paving Technologies, 64, 1995, 54-95
Google Scholar

Putman B.J., Amirkhanian S.N.: Utilization of Waste Fibers in Stone Matrix Asphalt Mixtures. Resources Conservation and Recyclcing, 42, 2004, 265-274
Google Scholar

Tayfur S., Ozen H., Aksoy A.: Investigation of Rutting Performance of Asphalt Mixture Containing Polymer Modifiers. Construction and Building Materials, 21, 2007, 328-337
Google Scholar

Sharma V., Goyal S.: Comparative Study of Performance of Natural Fibers and Crumb Rubber Modified Stone Matrix Asphalt Mixtures. Canadian Journal of Civil Engineering, 33, 2, 2006, 134-139
Google Scholar

Roberts. F.L., Kandhal P.S., Brown E.R., Lee D.Y., Kennedy T.W.: Hot Mix Asphalt Materials Mixture Design and Construction. NAPA Research and Education Foundation, Lanham, MD, 1996
Google Scholar

Decoene Y.: Contribution of Cellulose Fibers to the Performance of Porous Asphalts. Transportation Research Record, 1265, Transportation Research Board, National Research Council, Washington, D.C., 82, 1990, 82-86
Google Scholar

Chen J.S., Kueiyi L.: Mechanism and Behavior of Bitumen Strength Reinforcement Using Fibers. Journal of Material Science, 40, 1, 2005, 87-95
Google Scholar

Shaopeng W., Zheng C., Qunshan Y., Weidong L.: Effects of Fibre Additive on the High Temperature Property of Asphalt Binder. Journal of Material Science, 21, 1, 2006, 28-31
Google Scholar

Muniandy R., Bujang B.K.H.: Laboratory Diameteral Fatigue Performance of Stone Matrix Asphalt with Cellulose Oil Palm Fiber. American Journal of Applied Sciences, 3, 9, 2006, 2005-2010
Google Scholar

Muniandy R., Selim A.A., Hassim S., Omar H.: Laboratory Evaluation of Ground Tire Rubber in Stone Mastic Asphalt. The Journal of Engineering Research, 1, 2004, 53-58
Google Scholar

Specifications of Road and Bridge Works, the 4th revision. Ministry of Road Transport and Highways, Indian Roads Congress, New Delhi, India, 2001
Google Scholar

IS 15462:2004 Polymer and Rubber Modified Bitumen – Specifications, Bureau of Indian Standards, New Delhi, India
Google Scholar

ASTM 1559:1989 Test Method for Resistance of Plastic Flow of Bituminous Mixtures Using Marshall Apparatus, Annual Book of ASTM Standards, 04.03, ASTM International, West Conshohocken, PA
Google Scholar

Designing and Constructing SMA Mixtures-State of the Practice, Quality Improvement Series (QIS), 122, National Asphalt Pavement Association (NAPA), Lanham, MD, 1999
Google Scholar

Sikdar P.K., Jain S.S., Bose S., Kumar P.: Premature Cracking of Flexible Pavements. Journal of Indian Roads Congress, 60, 3, 1999, 355-398
Google Scholar

AASHTO T283 Resistance of Compacted Bituminous Mixture to Moisture Induced Damage, AASHTO, 2003
Google Scholar

IRC: SP: 79, 2008 Tentative Specifications for Stone Matrix Asphalt. Indian Roads Congress, New Delhi, India
Google Scholar

IRC: SP: 53, 2010 Guidelines on Use of Modified Bitumen in Road Construction. Indian Roads Congress, New Delhi, India
Google Scholar

Gajendra Kumar

gk.crri@gmail.com

Affiliation:

Central Road Research Institute (CSIR), Flexible Pavements Division, New Delhi-110025, India

Umesh C. Sahoo

Affiliation:

Indian Institute of Technology Bhubaneswar, School of Infrastructure, Odisha-752050, India

K. Ramachandra Rao

Affiliation:

Indian Institute of Technology Delhi, Department of Civil Engineering, and Transportation Research and Injury Prevention Programme (TRIPP), New Delhi-110016, India

Sunil Bose

Affiliation:

consultant in the field of Pavement Engineering, formerly - Central Road Research Institute (CSIR), New Delhi-110025, India

Design and evaluation of stone matrix asphalt using stiffer grade crumb rubber modified bitumen

Abstract

Keywords:

Similar Articles

Downloads

Gajendra Kumar

Umesh C. Sahoo

K. Ramachandra Rao

Sunil Bose