Badania mieszanek mineralno-asfaltowych z dodatkiem odpadowych pap bitumicznych

Piotr Zieliński

doi:10.7409/rabdim.022.016

Published: 2022-12-30

Vol. 21 No. 4 (2022)

Testing of asphalt mixtures containing an addition of reclaimed asphalt shingles

Piotr Zieliński

Section: Articles

https://doi.org/10.7409/rabdim.022.016

Abstract

The article presents test results of chosen properties of asphalt concrete mixtures with addition of asphalt shingle offcuts (reclaimed asphalt shingles, RAS). The presented research supplements previous works on the subject. Asphalt concrete AC 16 W 50/70 was adopted as the reference mixture. Results obtained for laboratory-produced mixture containing 4% RAS and plant-produced mixture containing 1% RAS were compared with the results of the reference mixture. Statistical analysis of void content in asphalt mixtures did not indicate significant differences; therefore, performance properties of mixtures may be compared without concern about the influence of physical properties. The research confirmed a significant increase in mixture stiffness with an increase in RAS content, especially at medium (15°C) and high (30°C) service temperatures. Compared to the reference mixture, mixtures incorporating RAS displayed an increase in indirect tensile strength as well. Lower temperature sensitivity of mixtures with RAS was also observed, both in terms of stiffness modulus and indirect tensile strength. Fatigue tests confirmed the positive effect of RAS on the obtained value of strain corresponding to fatigue life of 1 million load cycles.

Keywords:

asphalt mixtures, elastic stiffness modulus, fatigue characteristics, fatigue life, indirect tensile strength (ITS), reclaimed asphalt shingles (RAS).

Most read articles by the same author(s)

Malwina Spławińska, Piotr Zieliński, Piotr Burnos, Influence of traffic flow variability of heavy vehicles and temperature on pavement fatigue life , Roads and Bridges - Drogi i Mosty: Vol. 14 No. 2 (2015)

Download files

PDF (Język Polski)

Citation rules

Zieliński, P. (2022). Testing of asphalt mixtures containing an addition of reclaimed asphalt shingles. Roads and Bridges - Drogi I Mosty, 21(4), 277–292. https://doi.org/10.7409/rabdim.022.016

Cited by / Share

References

Pouranian M.R., Shishehbor M.: Sustainability Assessment of Green Asphalt Mixtures: A Review. Environments, 6, 6, 2019, 73, DOI: 10.3390/environments6060073
Google Scholar

Paulsen G., Stroup-Gardiner M., Epps J.: Roofing waste in asphalt paving mixtures – economic consideration, Report No. 6-331-709-1. Center for Construction Materials Research, University of Nevada, Reno, 1986
Google Scholar

Stroup-Gardiner M.: Use of Reclaimed Asphalt Pavement and Recycled Asphalt Shingles in Asphalt Mixtures, NCHRP Synthesis 495. Transportation Research Board, Washington, 2016, DOI: 10.17226/23641
Google Scholar

Hansen K.R., Copeland A.: Asphalt Pavement industry Survey on Recycled Materials and Warm-Mix Asphalt Usage: 2015. National Asphalt Pavement Association, Lanham, 2017
Google Scholar

Zieliński P.: Badanie mieszanek mineralno-asfaltowych z dodatkiem odpadów z produkcji bitumicznych gontów papowych (RAS). Zadanie w ramach działalności statutowej pt.: „Trwałe i przyjazne środowisku nawierzchnie drogowe”, nr: L2/282/2016/DS, Politechnika Krakowska, 2016
Google Scholar

Zieliński P., Mach A., Kostecka K.: Testing of the influence of manufacture waste asphalt shingles on the properties of hot mix asphalt. International Multidisciplinary Scientific GeoConference-SGEM, 17, 41, 2017, 245-252, DOI: 10.5593/sgem2017/41/S18.032
Google Scholar

Zieliński P.: Study of the possibility of increasing manufacture waste asphalt shingles additive to hot mix asphalt. International Multidisciplinary Scientific GeoConference-SGEM, 18, 4.2, 2018, 191-198, DOI: 10.5593/sgem2018/4.2/S18.025
Google Scholar

Zieliński P.: Effect of reclaimed asphalt shingles addition on asphalt concrete dynamic modulus master curves. Archives of Civil Engineering, 67, 3, 2021, 109-122, DOI: 10.24425/ace.2021.138046
Google Scholar

Kennedy T.W., Huber G.A., Harrigan E.T., Cominsky R.J., Hughes C.S., Von Quintus H., Moulthrop J.S.: Superior Performing Asphalt Pavements (Superpave): The Product of the SHRP Asphalt Research Program. National Research Council, Washington, 1994
Google Scholar

Zhou F., Button J.W., Epps J.: Best practice for using RAP in HMA, Report No. FHWA/TX-12/0-6614-1. Texas Transportation Institute, College Station, 2012
Google Scholar

Zhou F., Li H., Hu S., Button J.W., Epps J.A.: Characterization and best use of recycled asphalt shingles in hot-mix asphalt, Report No. FHWA/TX-13/0-6614-2. Texas A&M Transportation Institute, College Station, 2013
Google Scholar

Foxlow J.J., Daniel J.S., Swamy A.K.: RAP or RAS? The differences in performance of HMA containing reclaimed asphalt pavement and reclaimed asphalt shingles. Journal of the Association of Asphalt Paving Technologists, 80, 2011, 347-376
Google Scholar

AASHTO PP 78-14 Standard Practice for Design Considerations When Using Reclaimed Asphalt Shingles (RAS) in Asphalt Mixtures, 2016
Google Scholar

Williams R.C., Cascione A., Yu J., Haugen D., Marasteanu M., McGraw J.: Performance of recycled asphalt shingles in hot mix asphalt. Institute for Transportation, Iowa State University, Ames, 2013
Google Scholar

Wen H., Wu S., Zhang K., DeVol J., Kelsey K.: Performance evaluation of hot mix asphalt containing recycled asphalt shingles in Washington State. Transportation Research Board 93rd Annual Meeting, Washington, 2014
Google Scholar

Johnson E., Johnson G., Dai S., Linell D., McGraw J., Watson M.: Incorporation of Recycled Asphalt Shingles in Hot-Mixed Asphalt Pavement Mixtures, Report No. MN/RC 2010-08. Minnesota Department of Transportation, St. Paul, 2010
Google Scholar

Alvergue A.: Laboratory evaluation of asphalt mixtures and binders with reclaimed asphalt shingle prepared using wet process. LSU Master’s theses, 1205, Louisiana State University and Agricultural and Mechanical College, Baton Rouge, 2014, DOI: 10.31390/gradschool_theses.1205
Google Scholar

Darnell J., Bell C.A.: Performance based selection of RAP/RAS in asphalt mixtures, Report No. FHWA/OR-RD-16-08. Oregon Department of Transportation, Salem, 2015
Google Scholar

Diefenderfer S.D.: Evaluation of Stone-Matrix Asphalt Mixtures Containing Recycled Asphalt Shingles (RAS), Report No.: FHWA/VTRC 17-R22. Virginia Transportation Research Council, Charlottesville, 2017
Google Scholar

Kanaan A.I.: Impact of recycled asphalt shingles on asphalt concrete characteristics. Master of Science thesis, University of Illinois at Urbana-Champaign, Urbana, 2013, http://hdl.handle.net/2142/45354
Google Scholar

Koehl K.: Impact of recycling agents on the design of asphalt mixtures containing roofing shingles. 56th Annual IHEEP Conference, New Orleans, 2014
Google Scholar

Ozer H., Al-Qadi I.M., Kanaan A.: Laboratory Evaluation of High Asphalt Binder Replacement with Recycled Asphalt Shingles (RAS) for a Low N-Design Asphalt Mixture, Report No. FHWA-ICT-12-018. Illinois Center for Transportation, Rantoul, 2012
Google Scholar

Tighe S., Hanasoge N., Eyers B., Essex R., Damp S.: Who thought recycled asphalt shingles (RAS) needed to be landfilled: Why not build a road? 2008 Annual Conference of the Transportation Association of Canada, Toronto, 2008
Google Scholar

West R., Leiva F., Julian G., Taylor A., Brown E., Willis J.R.: Using Recycled Asphalt Shingles with Warm Mix Asphalt Technologies, NCHRP Research Report 890. Transportation Research Board, Washington, 2018
Google Scholar

McGraw J., Zofka A., Krivit D., Schroer J., Olson R., Marasteanu M.: Recycled asphalt shingles in hot mix asphalt. Asphalt Paving Technology: Association of Asphalt Paving Technologists-Proceedings of the Technical Sessions, 76, 2007, 235-274
Google Scholar

Vavrik W.R., Haugen D., Carpenter S.H., Gillen S., Behnke J., Garrott F.: Evaluation of HMA modified with recycled asphalt shingles (RAS) mixtures, Illinois State Toll Highway Authority, 2010
Google Scholar

WT-2 część I, Mieszanki mineralno-asfaltowe, Wymagania Techniczne. GDDKIA, Warszawa, 2014
Google Scholar

Bańkowski W.: Analiza trwałości zmęczeniowej betonów asfaltowych z uwzględnieniem typu mieszanki i rodzaju lepiszcza. Roads and Bridges - Drogi i Mosty, 17, 4, 2018, 253-270, DOI: 10.7409/rabdim.018.016
Google Scholar

Dobosz M.: Wspomagana komputerowo statystyczna analiza wyników badań. Akademicka Oficyna Wydawnicza EXIT, Warszawa, 2001
Google Scholar

Zaniewski J.P., Srinivasan G.: Evaluation of indirect tensile strength to identity asphalt concrete rutting potential. Graduate Theses, Dissertations, and Problem Reports, 1465, West Virginia University, Morgantown, 2003, DOI: 10.33915/etd.1465
Google Scholar

Christensen D.W., Bonaquist R.: Using the Indirect Tension Test to Evaluate Rut Resistance in Developing Hot-Mix Asphalt Designs. Transportation Research Circular, E-C124, 2007, 62-77
Google Scholar

Zieliński P.: Indirect tensile test as a simple method for rut resistance evaluation of asphalt concrete. Archives of Civil Engineering, 65, 3, 2019, 31-44, DOI: 10.2478/ace-2019-0032
Google Scholar

Zieliński P.: Indirect tensile test as a simple method for rut resistance evaluation of asphalt mixtures – Polish experience. Road Materials and Pavement Design, 23, 1, 2022, 112-128, DOI: 10.1080/14680629.2020.1820894
Google Scholar

Testing of asphalt mixtures containing an addition of reclaimed asphalt shingles

Abstract

Keywords:

Similar Articles

Most read articles by the same author(s)

Downloads

Piotr Zieliński