The assessment of stability at compression of steel pipes considering effects of uniform corrosion

Aniela Glinicka; Szymon Imiełowski

doi:10.7409/rabdim.019.018

Published: 2019-12-31

Vol. 18 No. 4 (2019)

The assessment of stability at compression of steel pipes considering effects of uniform corrosion

Aniela Glinicka , Szymon Imiełowski

Section: Articles

https://doi.org/10.7409/rabdim.019.018

Abstract

In aggressive environments structural steel components of engineering structures may become affected by corrosion. Even with corrosion protection, their critical load capacity and stability are seriously affected by the consequences of corrosion in aggressive environments due to impurities and possible failures. In this paper a critical state analysis of corroded struts is presented. The input data for the analysis was taken from laboratory corrosion tests in which steel pipes of a few different diameters were subjected to the attack of sulphuric and hydrochloric acids and placed in salt spray tester. The loss of material due to corrosion was determined and graphs, presenting the loss of material as a function of pipe diameter and the corrosion rate over time, were determined. The relative decrease of the maximum elastic strain energy which can be stored in the strut and the relative decrease of the critical load of elastic buckling were calculated for a series of corroded pipes. The curves of the relative change of the maximum elastic strain energy and the relative change of critical load over the time of corrosion progression were found to follow a similar path. For determining the critical load for a given strut, boundary conditions are taken into consideration. However, it is not necessary in the case of maximum elastic strain energy, which makes it a more convenient stability measure of the critical load capacity of strut.

Keywords:

buckling bars, corrosion rate, critical force, energy of elastic strain, elastic range, steel pipes.

Most read articles by the same author(s)

Szymon Imiełowski, Bartosz Śniegocki, Protection of pipeline bridges against vibrations caused by a water hammer , Roads and Bridges - Drogi i Mosty: Vol. 16 No. 1 (2017)
Aniela Glinicka, Cezary Ajdukiewicz, Szymon Imiełowski, Effects of uniformly distributed side corrosion on thin-walled open cross-section steel columns , Roads and Bridges - Drogi i Mosty: Vol. 15 No. 4 (2016)
Aniela Glinicka, Experimental analysis of inelastic buckling of short rectangular tubes , Roads and Bridges - Drogi i Mosty: Vol. 4 No. 2 (2005)
Aniela Glinicka, Magdalena Kruk, Experimental analysis of inelastic buckling of steel columns subjected to corrosion in the salt spray chamber , Roads and Bridges - Drogi i Mosty: Vol. 9 No. 3 (2010)
Szymon Imiełowski, Subcritical deformation of the bridge structure compressed members , Roads and Bridges - Drogi i Mosty: Vol. 20 No. 1 (2021)

Download files

PDF

Citation rules

Glinicka, A., & Imiełowski, S. (2019). The assessment of stability at compression of steel pipes considering effects of uniform corrosion. Roads and Bridges - Drogi I Mosty, 18(4), 267–281. https://doi.org/10.7409/rabdim.019.018

Cited by / Share

References

Nowak A.S., Szerszeń M.: Reliability profiles for steel girder bridges with regard to corrosion and fatigue. Journal of Theoretical and Applied Mechanics, 39, 2, 2001, 339-352
Google Scholar

Paik J.K., Shanifi Y.: Maintenance and repair scheme for corroded stiffened steel box girder bridges based on ultimate strength reliability and risk assessments. Engineering Structures and Technologies, 6, 3, 2014, 95-105
Google Scholar

Křivý V., Urban V., Kubzová M.: Thickness of Corrosion Layer on Typical Surfaces of Weathering Steel Bridges. Procedia Engineering, 142, 2016, 56-62
Google Scholar

Glinicka A., Ajdukiewicz C.: Skutki powierzchniowej korozji globalnej schodów stalowych. Autobusy, bezpieczeństwo i ekologia, 6, 2017, 171-174
Google Scholar

Wasilewska K., Glinicka A.: Corrosive and Mechanical Experimental Tests for Selected Stainless Steel Pipes. 28th Symposium on Experimental Mechanics of Solid, October 2018, Material Research Proceedings, Vol. 12, 2019, 31-36
Google Scholar

Roberge P.R.: Corrosion Engineering. Principles and Practice. McGraw-Hill, New York, USA, 2008
Google Scholar

Grzesiak P., Motała R.: Korozja stali w kwasie siarkowym. Instytut Ochrony Roślin - Państwowy Instytut Badawczy, Poznań 2008
Google Scholar

Glinicka A., Kruk M.: Analiza eksperymentalna wyboczenia niesprężystego prętów stalowych poddanych korozji w komorze mgły solnej. Roads and Bridges - Drogi i Mosty, 9, 3, 2010, 5- 22
Google Scholar

Glinicka A., Ajdukiewicz C., Imiełowski S.: Effects of uniformly distributed side corrosion on thin-walled open cross-section steel columns. Roads and Bridges – Drogi i Mosty, 15, 4, 2016, 257-270, DOI: 10.7409/radbim.016.016
Google Scholar

Glinicka A., Wasilewska K.: Wybrane efekty korozji rur stalowych w płaszczu ochronnym. International Conference Computer System Aided Science, Industry and Transport TRANSCOM, Logistyka, 6, 2009. CD transport building, 1-8
Google Scholar

Wasilewska K.: Wpływ korozji na nośność wybranych elementów stosowanych w sieciach komunalnych. Rozprawa doktorska, Politechnika Warszawska, WIL, Warszawa, 2014
Google Scholar

Królikowska A.: Zalecenia do wykonywania i odbioru antykorozyjnych zabezpieczeń konstrukcji stalowych drogowych obiektów mostowych. IBDiM, GDDKiA, Warszawa, 2006
Google Scholar

Baszkiewicz J., Kamiński M.: Korozja materiałów. Oficyna Wydawnicza Politechniki Warszawskiej, Warszawa, 2006
Google Scholar

Szydłowski H.: Teoria pomiarów. PWN, Warszawa, 1981
Google Scholar

Cramer S.D., Covino B.S. (ed): Environments and Industries, Handbook, Volume 13, ASM International 2006
Google Scholar

Glinicka A., Wasilewska K.: Badanie cech mechanicznych na próbkach z rur stalowych w płaszczu ochronnym po procesie korozji. Logistyka, 6, 2010, 931- 940
Google Scholar

Imiełowski Sz.: Deformacje, energia odkształcenia sprężystego w analizie stateczności konstrukcji inżynierskich. Seria wydawnicza „Studia z Zakresu Inżynierii”, Wyd. Komitetu Inżynierii Lądowej i Wodnej PAN, 102, Warszawa, 2019
Google Scholar

Odorowicz J.: Badania doświadczalne nad statecznością prętów pryzmatycznych o bardzo dużych smukłościach przy eulerowskich obciążeniach krytycznych. Teoretyczne zagadnienia mechaniki konstrukcji stalowych i zespolonych. Oficyna Wydawnicza Politechniki Warszawskiej, Prace Naukowe Politechniki Warszawskiej, Budownictwo, 138, 2001, 29-74
Google Scholar

Kossakowski P.: Load carrying capacity of steel railway bridges subjected to long term service according to Eurocode Standards. Roads and Bridges - Drogi i Mosty, 13, 2, 2014, 115-130, DOI: 10.7409/rabdim.014.008
Google Scholar

Aniela Glinicka

A.Glinicka@il.pw.edu.pl

Affiliation:

Warsaw University of Technology, Faculty of Civil Engineering, 16 Armii Ludowej av., 00-637 Warsaw

Szymon Imiełowski

Affiliation:

Warsaw University of Technology, Faculty of Building Services, Hydro and Environmental Engineering, 20 Nowomiejska str., 00-653 Warszawa

The assessment of stability at compression of steel pipes considering effects of uniform corrosion

Abstract

Keywords:

Similar Articles

Most read articles by the same author(s)

Downloads

Aniela Glinicka

Szymon Imiełowski