Roads and Bridges - Drogi i Mosty
2, 4, 2003, 63-98

Thin bonded concrete overplays for strengthening of road pavement. Part I

Agnieszka Żurawicka Mail
Road and Bridge Research Institute, Żmigród

Abstract

The first part of the paper describes the technology that is used over the world for the pavement rehabilitation the strengthening of existing pavements with thin bonded concrete overlays. On the basis of the review of numerous case studies the experience gained during observation of overlays on concrete and asphalt substrate is presented. The factors that affect the performance of concrete overlays and recommended procedures for design and construction of these overlays are also discussed. In the following part of the paper full scale tests of thin bonded concrete overlays will be presented.

Full Text:

PDF PDF

References


Wysokowski A., Żurawicka A.: Analiza możliwości wzmacniania płyt betonowych cienkimi warstwami fibrobetonów. III Konferencja Naukowo-Techniczna „Zagadnienia materiałowe w Inżynierii Lądowej MATBUD’2000, Kraków 2000. 370-376

Rowden L.: Thin Bonded Concrete Overlay and Bonding Agents. Physical Research Report No. 123, Bureau of Materials and Physical Research, Illinois Department of Transportation, Springfield 1996

Delatte N.J.: Interface Stresses and Bond Strength in Bonded Concrete Overlays. Transportation Research Board 78th Annual Meeting, Washington D.C. 1999

Granju J. L., Chausson H.: Fiber reinforced thin bonded overlays: the mechanism of their debonding in relation with their cracking. Concrete Repair, Rehabilitation and Protection, edited by R.K.Dhir and M.R. Jones, E&FN Spon, London, 1996, 583-590

Granju J.L., Turatsinze A., Farhat H.: Les paradoxes de la durabilite des recharge-ments minces adherents. Actes du troisićme colloąue international francophone sur les betons renforces de fibres metalliąues, ed. par R. Pleau et M. Pigeon, Universite Laval, 65-76, Quebec 1998

Granju J.L.: About the debonding of thin cement-based overlays. Fracture Mecha-nics of Concrete Structures, (Proc. of FRAMCOS 3 Conference, 1998, Gifu, Japan), ed. by H. Mihashi & K. Rokugo, AEDIFICATIO Publ., 3, Freiburg 1998

Delatte N.J., Laird J.T.: Performance of Bonded Concrete Overlays. Transportation Research Board 78th Annual Meeting, Washington D.C. 1999

Neal B.F.: California’s Thin Bonded PCC Overlay. Report No. FHWA/CA/TL-83-04, Sacramento, California 1983

Lundy J.R., McCullough F.: Delamination in Bonded Concrete Overlays of Continuously Reinforced Pavement. 4th International Conference on Concrete Pavement Design and Rehabilitation, Purdue University, West Lafayette 1989, 221-229

Verhoeven K., Yancraeynest Y.: Thin Steel Fiber Reinforced Concrete Overlays and Inlays on Old Pavements - A Ten Year Belgian Experience. 5th International Conference on Concrete Pavement Design and Rehabilitation, 203-210,2, Purdue University, West Lafayette 1993

Ibukiyama S., Kokubun S., Ishikawa K.: Introduction of Recent Thin Bonded Concrete Overlay Construction and Evaluation of Those Performances in Japan. 4th International Conference of Concrete Pavement Design and Rehabilitation, 193-203, West Lafayette 1989

Delatte N.J., Grdter S.F., Trevińo-Farias M., Flower D.W., McCullough B.F.: Partial Construction Report of a Bonded Concrete Overlay on IH-10, El-Paso and Guide for Expedited Bonded Concrete Overlay Design and Construction. Report 2911-5F, Center for Transportation Research, The University of Texas at Austin, 1996

Chanvillard G., Aitcin P.C., Lupien C: Field Evaluation of Steel-Fiber Reinforced Concrete Overlay with Various Bonding Mechanisms. Transportation Research Board 69th Annual Meeting, Washington D.C. 1990, 48-56

King W.M.: Design and Construction of a Bonded Fiber Concrete Overlay of CRCP. Report No. FHWA/LA-92/266 Louisiana Transportation Research Center, 1993

SilJwerbrand J., Petersson O.: Thin Concrete Inlays on Old Concrete Roads. 5th International Conference on Concrete Pavement Design and Rehabilitation, 2, Purdue University, West Lafayette 1993, 255-260

Volle T.H.: Thin Bonded Concrete Overlays in Illinois: Preliminary Report on Performance. Transportation Research Board 80th Annual Meeting, Washington D.C. 2001

Sprinkel M., Ozyildirim C.: Evaluation of Hydraulic Cement Concrete Overlays Placed on Three Pavements in Virginia. 7th International Conference on Concrete Pavements, Orlando 2001

Rolla S.: Beton na asfalt - Whitetopping. Drogownictwo, 6/2000, 171-175

Cole L.W., Mack J.W.: Thin Bonded Concrete Overlays of Asphalt Pavement. Publikacja na stronie internetowej American Concrete Pavement Association ACPA

Webb R., Delatte N.J.: Performance of Whitetopping Overlays. Transportation Research Board 79th Annual Meeting, Washington D.C. 2000

Hutchinson R.L.: Resurfacing with Portland Cement Concrete. NCHRP Synthesis 99. TRB, National Research Council, Washington D.C. 1982

McGhee K.H.: Portland Cement Concrete Resurfacing. NCHRP Synthesis 204 TRB, National Research Council, Washington D.C. 1994

Guidelines for Concrete Overlays of Existing Asphalt Pavements (Whitetopping) Technical Bulletin. TB-0090D, American Concrete Pavement Association, Skokie 1991

Caestecker Ch., Lonnewc T, Haemels F.: UTW: Test Section at Vilvoorde on the R22 in Belgium. 7th International Conference on Concrete Pavement, Orlando 2001

Tarr S.M., Sheehan M.J., Ardani A.: Mechanistic Design of Thin Whitetopping Pavements in Colorado. Transportation Research Board 79th Annual Meeting, Washington D.C. 2000

Design of Concrete Overlays (Whitetopping) for Asphalt Parking Lots. Pamphlet No. 153, Portland Cement Association, Skokie 1989

MackJ. W., Cole J.W., Mohsen J.P.: Analytical Considerations for Thin Concrete Overlays on Asphalt. Transportation Research Board 72nd Annual Meeting, Washington D.C. 1993

Mack J.W., Wu Ch.L., Tarr S., Refai T.: Model Development and Interim Design Procedure Guidelines for Ultra-thin Whitetopping Pavements. 6th International Conference on Concrete Pavement Design and Materials for High Performance, Purdue University, 1, Indianapolis 1997, 231-256

Wu C, Tarr S., Ardani A., Sheehan M.: Instrumentation and Field Testing of Ultra-thin Whitetopping Pavement. Transportation Research Board 77th Annual Meeting, Washington D.C. 1998

Wu C, Tarr S, Refai T.M., Nagi M.A., Sheehan M.: Development of Ultra-thin Whitetopping Design Procedure. PCA R&D Serial No. 2124, PCA, Skokie 1998

Mack J.W., Hawbaker L.D., Cole L.W.: Ultra-thin Whiteopping (UTW): The State-of-the-Practice for Thin Concrete Overlays of Asphalt. Transportation Research Board 77th Annual Meeting, Washington D.C. 1998

American Concrete Pavement Association, Whitetopping - State of the Practice. Engineering Bulletin EB210P, 1998

Tarr S.M., Sheehan M.J., Okamoto P.A.: Guidelines for the Thickness Design of Bonded Whitetopping Pavement in the State of Colorado. Report No. CDOT-DTD-R-98-10, 1998

Risser R.J., LaHue S.P., Voigt G.F., Mack J.W.: Ultra-Thin Concrete Overlays on Existing Asphalt Pavement. 5th International Conference on Concrete Pavement Design and Rehabilitation, 2, Purdue University, West Lafayette 1993, 247-254

Silfwerbrand J.: Whitetoppings - Swedish Field Tests and Recommendations. 6th International Conference on Concrete Pavement Deign and Materials for High Performance, Purdue University, 2, 1997, 231-243

Cable J.K, Hart J., Ciha T: The Ultrathin Whitetopping Option. 7th International Conference on Concrete Pavement - Orlando, Florida 2001

Wu Ch.L., Sheehan M.J.: Testing and Performance Evaluation of UTW Pavements at the Spirit of St. Louis Airport. Transportation Research Board 81st Annual Meeting, Washington D.C. 2002

Vandenbossche J.M., Fagerness AJ.: Performance and Repair of Ultra-Thin Whitetopping: the Minnesota Experience. Transportation Research Board 81 st Annual Meeting, Washington D.C. 2002

Full-Scale Accelerated Testing of Ultra-Thin Whitetopping Pavements. Tech Brief, Publication No. FHWA-RD-99-087, Federal Highway Administration, Virginia 1999

Rajan S., Olek J., Robertson T.L., Galal K., Nantung T, Weiss W.J.: Analysis of Performance of Ultra-Thin Whitetopping Subjected to Slow Moving Loads in an Accelerated Pavement Testing Facility. 7th International Conference on Concrete Pavement, Orlando 2001

Chausson H., Granju J.L.: Optimized Design of Fiber Reinforced Thin Bonded Overlays. Int. Symp. Brittle Matrix Composites 5, ed. by A.M. Brandt, V.C. Li, I.H. Marshall, BIGRAF and Woodhead Publ. Ltd, 133-142, Warsaw 1997

Granju J.L., Pigeon M., Grandhaie F., Banthia N.: Pavements Repairs with Metallic Glass Fiber Reinforced Concrete: Laboratory and Field Studies of Durability. ACI International Conference on Evaluation and Rehabilitation of Concrete Structure and Innovation in Design, Hong Kong 1991, 162-182

Granju J.L., Grandhaie F.: Thin Repairs with Metallic Fiber Reinforced Concrete: Length Changes during the First 24 Hours. 4th RILEM International Symposium on Fiber Reinforced Cement and Concrete, Sheffield 1992, 676-689

Faleńska M., Gajger W.: Wzmocnienie wyeksploatowanych nawierzchni asfaltowych przy wykorzystaniu nakładki z betonu cementowego. VII Międzynarodowa Konferencja „Trwałe i Bezpieczne Nawierzchnie Drogowe”, Kielce 2001, 43-50

Suh Y.C., Lundy J.R., McCullough B.F., Fowler D.W.: A Summary of Studies of Bonded Concrete Overlays, Research Report 457-5F. Center for Transportation Research, The University of Texas at Austin, 1988


Thin bonded concrete overplays for strengthening of road pavement. Part I

  
Żurawicka, Agnieszka. Thin bonded concrete overplays for strengthening of road pavement. Part I. Roads and Bridges - Drogi i Mosty, [S.l.], v. 2, n. 4, p. 63-98, dec. 2014. ISSN 2449-769X. Available at: <>. Date accessed: 08 May. 2021.